Just wondering peoples thoughts. I have a 96' 75 series cruiser tray diesel. Got it serviced today and we have noticed that bubbles are comin into the resiorvor when it is idleing.. has not got hot for a couple of years, problem then was the fan,. do you's think it would be more likely to be the head or the gasket? 2 year old radiator, new cap and has been running good. Hasn't been used as much lately either.
Any ideas let me know,
Thanks
Notice: We request that you don't just set up a new account at this time if you are a previous user.
If you used to be one of our moderators, please feel free to reach out to Chris via the facebook Outerlimits4x4 group and he will get you set back up with access should he need you.
If you used to be one of our moderators, please feel free to reach out to Chris via the facebook Outerlimits4x4 group and he will get you set back up with access should he need you.
Recovery:If you cannot access your old email address and don't remember your password, please click here to log a change of email address so you can do a password reset.
Bubbles in radiator
Moderators: toaddog, TWISTY, V8Patrol, Moderators
I dont know about bubbles in the resevour...but pull the radiator cap off while the motor is running (obviously not when hot), if you see bubbles there then its a good guess that the head gasket/head has problems.
Also check the oil...if it has got a milky look to it, then that confirms head gasket/head.
Has it been using a lot of water/oil lately?
Also check the oil...if it has got a milky look to it, then that confirms head gasket/head.
Has it been using a lot of water/oil lately?
L.S Canvas & P.V.C
www.lscanvas.com.au
www.lscanvas.com.au
Did they do a radiator fluid change when it was serviced? Could be some residual air pockets bein purged from the heater circuit. Take the radiator cap off while it is cool and warm it up without the radiator cap on and see if the bubbles start appearing again.
See if it uses any water over the next couple of days.
Could still be a leak from cyl-waterjacket, without involvement of the oil channels....(don't always get milky oil with a blown gasket...)
See if it uses any water over the next couple of days.
Could still be a leak from cyl-waterjacket, without involvement of the oil channels....(don't always get milky oil with a blown gasket...)
George Carlin, an American Comedian said; "Think of how stupid the average person is, and realise that half of them are stupider than that".
As a motor mechanic I've seen a few vehicles with bubbles the radiator and not had a blown gasket or cracked head. Some can be caused by air sucking in around the water pump seal but this only happens when the cooling system is not under pressure, ie with the cap off. I have a carbon monoxide sniffer that samples air releasing from the radiator, perhapes someone in your area has one. If u have a blown gasket etc at this stage and it's only a small breach it will be hard to detect just by looking once the head comes off. Even with crack testing the head for a small crack is not allways a surething. If ur only symptom is a few bubbles I'd wait and see what happens. It'll either get better(great) or worse, but at lest the problem will be easier to find. The worst thing is u pull the head off and find nothing wrong, then what? put the head back on and hope it's fixed.
Those who choose to drive in the mud do so because they can't drive the rocks.
Yeah thanks mate i might try and c if iwe can test it like u said.. just had a play in the shed then and it is fine no bubbles at all till it heats up then they start.. i just dont want to do nothing about it then do more damage if it gets hot and i happened to miss it for some reason.. thanks for your imput guys.. was keen for a spin on weekend but not sure now... ahh the fun and games of it all
Yes, as the gun says sometimes it might not be that obvious once you do pull the head off. A minor breach of the head gasket is not always easy to pick up particularly if you don't have much experience and not all cracks are visible to the naked eye, especially when the head is at room temperature. Not sure if you have had it anylised at a workshop, but I would first take it to a reputable shop and have them anylise the cooling system, pressure testing, and as said above, sniffing the air released from the radiator.
A good head specialist will be able to pressure test the head on the bench and do crack detection. If you do it yourself and don't have the head checked and machined (if necessary), you run the risk of not fixing the problem.
A good head specialist will be able to pressure test the head on the bench and do crack detection. If you do it yourself and don't have the head checked and machined (if necessary), you run the risk of not fixing the problem.
Everytime I've seen bubbles in the radiator its been a blown headgasket/cracked head. If you can swing a hammer and can take the head off yourself you can basically do the job for the cost of a gasket before doing any further damage as you say.
2002 Hilux Dual Cab - 2.7L Pet 5spd - TJM Steel Bullbar - 31" Wrangler MTR's - Lightforce 240's - Backyard Custom's Roof Console & DIN Slot Panel
Who is online
Users browsing this forum: No registered users and 115 guests