Though I haven't installed this system yet, in the instructions it says that sometimes peoples charging system is too small. By that I guess they mean the alternator doesn't put out enough? If my alternator was the standard one in an 88 hilux diesel ( 2.4 ) I guess it is only like 50 amps or so? Is that big enough to run a big aux battery? When I go away I will be running 1-2 lights and a medium size engel. Pretty much it.
The only accessories I have on my car is a small 2 speaker stereo, 2x100w spotties and a uhf ( all hardly get used ). I have 2x50w lights on the rear but I use them for very short bursts ( to see in the dark when unpacking ).
So what yas reckon? Is a standard alternator fine to slowly charge my main battery as well as a decent sized aux bat ?
Cheers guys. I really want the heads up on this.
Notice: We request that you don't just set up a new account at this time if you are a previous user.
If you used to be one of our moderators, please feel free to reach out to Chris via the facebook Outerlimits4x4 group and he will get you set back up with access should he need you.
If you used to be one of our moderators, please feel free to reach out to Chris via the facebook Outerlimits4x4 group and he will get you set back up with access should he need you.
Recovery:If you cannot access your old email address and don't remember your password, please click here to log a change of email address so you can do a password reset.
Dual battery kit says my charging system could be too small?
Moderator: -Scott-
Given how old this is I imagine you've figured the go through trial and error but since no one else did...
I have had a dual battery in my truck for a couple of years with the std alternator. It's an old GQ which has a pissy 50A alternator. It has worked fine for me the whole time. It does depend on how much time you spend moving and how much time stationary, and the heat. I have had the Aux power the fridge for a full 5 days in cold conditions, and about 30hrs in hot ones. I find that the battery only charges properly when I'm driving, ie not at idle. A couple hours drive tends to get it topped up, so if you don't do much driving with your camping you may need a bigger alt or solar.
I have now just added a third battery to the back for extended stays to get some more life out of it. I picked up a neat little unit from jaycar which is a voltmeter and inside/outside themometer in one. I have rigged it up to the back battery and mounted it on the back of the storage system I built facing forward. Now can monitor the voltage and fridge temp from the drivers seat or from outside the car. Third battery has been in only a few days but is definitely charging OK off the std alt. Was sitting at about 12.3V which is low, about 15mins driving got it up to 12.7 where it belongs. Can also see that while I'm driving it's sitting at 13.4-13.7 indicating charging is going on. Should mention I ran 4 gauge cable to the back battery. Used to be 8 gauge when it just powered the fridge and a Fluro.
More than you wanted to know I'm sure!
I have had a dual battery in my truck for a couple of years with the std alternator. It's an old GQ which has a pissy 50A alternator. It has worked fine for me the whole time. It does depend on how much time you spend moving and how much time stationary, and the heat. I have had the Aux power the fridge for a full 5 days in cold conditions, and about 30hrs in hot ones. I find that the battery only charges properly when I'm driving, ie not at idle. A couple hours drive tends to get it topped up, so if you don't do much driving with your camping you may need a bigger alt or solar.
I have now just added a third battery to the back for extended stays to get some more life out of it. I picked up a neat little unit from jaycar which is a voltmeter and inside/outside themometer in one. I have rigged it up to the back battery and mounted it on the back of the storage system I built facing forward. Now can monitor the voltage and fridge temp from the drivers seat or from outside the car. Third battery has been in only a few days but is definitely charging OK off the std alt. Was sitting at about 12.3V which is low, about 15mins driving got it up to 12.7 where it belongs. Can also see that while I'm driving it's sitting at 13.4-13.7 indicating charging is going on. Should mention I ran 4 gauge cable to the back battery. Used to be 8 gauge when it just powered the fridge and a Fluro.
More than you wanted to know I'm sure!
Re: Dual battery kit says my charging system could be too sm
If this is all you have then why on earth are you even bothering with a 2nd battery?Turbz wrote:The only accessories I have on my car is a small 2 speaker stereo, 2x100w spotties and a uhf ( all hardly get used ). I have 2x50w lights on the rear but I use them for very short bursts ( to see in the dark when unpacking ).
Unless you have a fridge then I wouldn't bother.
Land Rover Discovery series 1 V8
I also run a 32litre engel. But to update things, I emailed Matson about it and they swiftly replied with a nice understanding email.
They said " Your alternator will have no problem keeping up with your 2 batteries, it should put out around 14V- 14.4V. It’s also a good idea to give the auxiliary battery a charge on a good quality switchmode charger every now and then to keep it in good condition and prolong battery life ".
Good to know. ! CHEERS MATSON!
They said " Your alternator will have no problem keeping up with your 2 batteries, it should put out around 14V- 14.4V. It’s also a good idea to give the auxiliary battery a charge on a good quality switchmode charger every now and then to keep it in good condition and prolong battery life ".
Good to know. ! CHEERS MATSON!
Who is online
Users browsing this forum: No registered users and 12 guests