Notice: We request that you don't just set up a new account at this time if you are a previous user.
If you used to be one of our moderators, please feel free to reach out to Chris via the facebook Outerlimits4x4 group and he will get you set back up with access should he need you.
Recovery:If you cannot access your old email address and don't remember your password, please click here to log a change of email address so you can do a password reset.

HELP.. Removing 60 series hubs

Tech Talk for Cruiser owners.

Moderators: toaddog, Elmo, DUDELUX

Post Reply
Posts: 165
Joined: Wed Jun 08, 2005 7:25 pm
Location: Gympie, QLD

HELP.. Removing 60 series hubs

Post by whoneedsbitumen »

Im in the process of pulling the hubs of to do the front bearings and inner seals,
i have removed the hub cover and the 6 nuts and spring washers i need to know to get those cone washers out to remove the hub body?
it says in the book to use a suitable pin punch and hammer to remove them but how?.. all i have is a hammer and screwdriver :twisted:

thanks

Adam
'91 75 Diesel Ute
33 Maxxis Buckshots
GME TX3200
Magellan Explorist 400
Heavy Right Foot
Posts: 6029
Joined: Tue Dec 24, 2002 9:34 pm
Location: South Australia

Re: HELP.. Removing 60 series hubs

Post by bad_religion_au »

whoneedsbitumen wrote:Im in the process of pulling the hubs of to do the front bearings and inner seals,
i have removed the hub cover and the 6 nuts and spring washers i need to know to get those cone washers out to remove the hub body?
it says in the book to use a suitable pin punch and hammer to remove them but how?.. all i have is a hammer and screwdriver :twisted:

thanks

Adam
tap the side of the hub. they should pop out

or get a new set of studs (like 1 buck each) and hit the studs head on pretty hard. that should pop the cone washers, and any threads you stuff, big deal, your replacing them anyway.
Spit my last breath
Posts: 6021
Joined: Sat Feb 15, 2003 11:01 pm
Location: Shed.

Post by dumbdunce »

put the nuts back on until the ends of the studs are flsh with the studs. use a brass drift and give the ends of the studs a sharp whack. you can also tap the side of the hub adjacent to the stud but if you deform the hub the cne will not re-seat properly. If they haven't been off in a long time, soak in WD40 or similar, back off the nuts one turn, put it in 4WD and go for a bit of a drive - 5 - 10km, then give it a try. if you use this method, it's best to replace the studs.
Free air locker to the first 20 callers!
Posts: 100
Joined: Fri Jun 22, 2007 5:47 pm
Location: Stafford, BRISBANE

mm

Post by turbo42 »

Posts: 2765
Joined: Wed Jan 14, 2004 10:32 pm
Location: somewhere out there

Post by shorty_f0rty »

i have a high tensile bolt+nut that I partly screw onto the ends of the stud.. i give this a few bashes to pop out the cone washer.. so far it doesnt seem to to have damaged the thread on the stud yet...

this bolt is also used to screw into the cv shaft so i can pull it out when replacing the snap ring..

what are other peoples thoughts on this method? advised or not?

i havent got a hold of a brass drift yet...
Built, not bought!
'84 BJ42 - sold! :(
'79 Coiled and turbo diesel'd FJ55
Posts: 3038
Joined: Thu Aug 05, 2004 10:06 pm
Location: VIC

Post by dogbreath_48 »

I use a brass drift and give the studs a good few hard whacks. Never thought of leaving the nut on for a bit of extra safety but i've never damaged the threads using the drift.

-Stu :)
Tetanus rolling on 37's
Resident Terrorist
Posts: 4278
Joined: Fri May 21, 2004 9:37 am
Location: Driving Barnsey's mum to bingo

Post by RAY185 »

dogbreath_48 wrote:I use a brass drift and give the studs a good few hard whacks. Never thought of leaving the nut on for a bit of extra safety but i've never damaged the threads using the drift.

-Stu :)
x2

Some leave the nuts on to reduce the chance of losing a collet, they tend to get very camoflaged once they hit the deck.
Posts: 382
Joined: Fri Dec 06, 2002 8:15 pm
Location: Diamond Creek

Post by DNA Off Road »

shorty_f0rty wrote:i have a high tensile bolt+nut that I partly screw onto the ends of the stud.. i give this a few bashes to pop out the cone washer.. so far it doesnt seem to to have damaged the thread on the stud yet...

this bolt is also used to screw into the cv shaft so i can pull it out when replacing the snap ring..

what are other peoples thoughts on this method? advised or not?

i havent got a hold of a brass drift yet...
Life can be so much easier with the right tools - shout yourself a good brass drift - Tradetools have then cheap as chips....

Cheers
Stock 'Cruiser X 2
www.dnaoffroad.com.au
Posts: 165
Joined: Wed Jun 08, 2005 7:25 pm
Location: Gympie, QLD

Post by whoneedsbitumen »

Thanks guys worked all that out in the end, nothing that a hammer couldnt fix, now i just got to get the inner oil seal out

any suggestions to make it easier than destroying it with a screwdriver ?
'91 75 Diesel Ute
33 Maxxis Buckshots
GME TX3200
Magellan Explorist 400
Heavy Right Foot
User avatar
udm
Posts: 659
Joined: Tue Apr 26, 2005 8:35 pm

Post by udm »

whoneedsbitumen wrote:now i just got to get the inner oil seal out

any suggestions to make it easier than destroying it with a screwdriver ?
no matter what you use, you will destroy it, its a seal that you want to replace everytime you are in there anyway, only about $5 each.
Ulises

www.OzSigns.com - 0400008422
Posts: 6029
Joined: Tue Dec 24, 2002 9:34 pm
Location: South Australia

Post by bad_religion_au »

whoneedsbitumen wrote:Thanks guys worked all that out in the end, nothing that a hammer couldnt fix, now i just got to get the inner oil seal out

any suggestions to make it easier than destroying it with a screwdriver ?

you are going to replace the seal right?

so destroy it
Spit my last breath
Posts: 505
Joined: Wed Jan 25, 2006 9:19 am
Location: to the left of the post

Post by trains »

Tap a small flat head screw driver into the side of it, making sure you dont damage the inner part of the diff.
Twist slightly, this should now allow you to put the screw driver between the seal, and diff housing, a gentle twist, and it should pop out.

When fitting new seal, apply very thin smear of gorilla snot to its outside, and gently, and evenly tap in the new seal with a large flat faced punch, or if you have it, a socket just undersize of the seal.
Apply plenty of rubber grease to the inside of the seal where it runs on the axle, and also put some on the axle, being carefull as you re insert the axle that it dosent tear, or rub on the new seal when you refit it.

T
Save the Whales......Collect the whole set.


My Wife Can't Shear..............But You Should See Her Crutch !
Post Reply

Who is online

Users browsing this forum: No registered users and 1 guest