Notice: We request that you don't just set up a new account at this time if you are a previous user.
If you used to be one of our moderators, please feel free to reach out to Chris via the facebook Outerlimits4x4 group and he will get you set back up with access should he need you.
Recovery:If you cannot access your old email address and don't remember your password, please click here to log a change of email address so you can do a password reset.

1.3 ltr zook runnin up to 20 pound boost wooopsies

Tech Talk for Suzuki owners.

Moderators: lay80n, sierrajim

Forum rules
Post Reply
Posts: 1508
Joined: Fri Aug 15, 2008 10:45 am
Location: gladstone qld

1.3 ltr zook runnin up to 20 pound boost wooopsies

Post by Mosko111 »

hey guys i have a 1.3 litre suzi with a turbo bolted on the side of it suposively its a bobcat turbo but it was only running 5 pound boost with the controls wound right up but on the weekend the adjustment toggle fell apart and now its running a stupid amount of boost, i can drive it to ablout 10 pound and it runs fine but have to short shift through the gears but if it goes any higher pre-ignition starts happening, just wonder how long until it blows up haha, and why couldnt i wind it up to that amount of psi before it fell apart?
Top
Posts: 810
Joined: Tue Jul 08, 2008 8:40 pm
Location: vic

Post by ajsr »

your wastegate is probably not operating at all now
fix it fast before you grenade that motor . those lbs boost require some serious motor and fuel to run properly
85 high roof 1.3, 6.5 tc, air lockers,ruf and 34 swampers. yep its an ugly pos.
Top
Posts: 122
Joined: Mon Jul 16, 2007 9:32 pm
Location: Toowoomba

Post by neil_se »

Driving it as is i'd give it a few days before you do the headgasket or piston ring. It sounds like its just free-boosting ie. the wastegate isn't opening at all.
Top
Posts: 2066
Joined: Mon Jun 09, 2003 8:17 pm
Location: Gympie

Post by Rhett »

Did you build this car or buy it? Ive been told of it before. its a hard top cut down into a ute yes?
Its a wheelbase thing
Top
Posts: 124
Joined: Sun Dec 09, 2007 12:53 pm
Location: eastern suburbs, victoria

Post by lilzook »

sounds like the line going from the compressor housing to the wastegate is cut/split so your car is boosting to atmospheric pressure.

Dont drive the car like this. dont let the boost build above what it was tuned to (5psi). Anything over that can blow your motor if you dont have the right air/fueling. also the extra pressure on the internals and h/gasket will probably break something.
Top
Posts: 1508
Joined: Fri Aug 15, 2008 10:45 am
Location: gladstone qld

Post by Mosko111 »

yeah mate thats then one little orange zook cut into a ute, its just my daily driver because i dont want the cops to cathc me with the cruiser on the road theyd bend me over and ass rape me for having 36's on the road haha, but yeah it was the actual boost control that fell apart, just going to put a new one in, so far shes been going like that for 2 weeks i dont over rev it and short shift before it gets to about 10 pound boost,
Top
Posts: 124
Joined: Fri Aug 17, 2007 11:48 am
Location: lonnie

Post by FC3892 »

the boost will come on with load, not revs! pull your foot out as the boost come up big fella. but it sounds like the boosted line to the WG has come off. A low comp 1.3 zook motor will take a bit to pop.. but ide not be boosting it up to 20 less u enjoy pulling things apart

Adam
Top
Post Reply

Return to “Suzuki”

Who is online

Users browsing this forum: No registered users and 3 guests