hilux turbo diesel

[DAV029]

just bought a 2L hilux turbo diesel it drives well but will not rev past 3000 rpm is that normal or do i have dramas and if so what could it be?took the air filter out and drove it but no change . its my first diesel turbo so i have no idear

[Nat84]

i don't think it is good to be reving it that hard i have a 2L non turbo and just geting it to 3000 is a fight

[zookdave]

any diesels arent meant to rev as quickly or as high as a petrol but 3000rpm sounds quite bad. how old is the engine?? it might just have dirty oil or didnt get serviced very often.

[DAV029]

any diesels arent meant to rev as quickly or as high as a petrol but 3000rpm sounds quite bad. how old is the engine?? it might just have dirty oil or didnt get serviced very often.

dont know how old it is. my my 2L 4runner non turbo diesel revs to 4400
and is near dead so we bought this lux to do a trancfer i

[Sic Lux]

could have the bolt that stops the cable from moving to far wound in or streched cable get someone to sit in it and rev it by pedal then get the throttle assembly and try turn it futher look for something restricting it also what about a fuel filter could be claged up and not letting it flow enough to get decent RPM

[DAV029]

could have the bolt that stops the cable from moving to far wound in or streched cable get someone to sit in it and rev it by pedal then get the throttle assembly and try turn it futher look for something restricting it also what about a fuel filter could be claged up and not letting it flow enough to get decent RPM

throttle cable is good . i missed the fillter do that tonight and see wht happens thanks mate

[MitchellBros4x4]

Crack the supply line off the back of the injectors and use some brake or carby cleaner to clean them up a bit and check the fine gauze filter behind the fuel cut solenoid. If either of these gets caked up they will not help.

[DAV029]

2.4 turb ,2.4 non turb are they the same motor ,compression ect ,if so can i un bolt the turbo and bolt it straight to my other motor and get a tune up . the turb motor still running like a 3 leged pig

[tweak'e]

2.4 turb ,2.4 non turb are they the same motor ,compression ect ,if so can i un bolt the turbo and bolt it straight to my other motor and get a tune up . the turb motor still running like a 3 leged pig

there are 2 different types, the early 2.4 are not interchangable with the later ones. need to know which type you have.

do the usual serviing first, oil change fuel filter change etc.

is it blowing smoke at all ?
if not it could be under fueling eg blocked fuel hose or some has adjusted the pump.
check the throttle isn't being stopped to early.
check EGR is blocked off. quite comman for these to be stuck open and it makes the motor run like crap.
check cam belt timing, mayby its slipped a tooth.