Outer Limits 4x4 Board

Yep looked with search, found nothing useful.

We have had a strange thing happen this week in melbourne it RAINED!
So whilst i'm driving though the aformentioned phenomenon ,my boots and socks were filling up with water.
Its dripping from under the dash everywhere and now i know why the floor was Rooted!
Is there hosing or a blocked tray that i should be lookin for?

Cheers in advance for and help
Steve
Oh and by the way i've got the beast on the road thanks for all suggestions and help so far


She always was destined to have 1 of her own!

this is what i did to fix the problem.
i call it sheps wet foot stopper
http://www.auszookers.com/index.php?nam ... sc&start=0

Thanks SHEPS,
Well made but isn't that an air inlet for the vents and heater?
You said that it was a crappy rubber seal.. on the heater box or where it joins up to the vents in the firewall?
Does the dash need to be stripped out to get at it?
I don't mind where it is but i don't want to pull appart the whole car for an easy to get at issue!
Has anyone else repaired one?


Steve

check the vent tubes arent blocked also going into the engine bay.

If it hasnt been done in years, you should clean out the heaterbox anyway, so my advice would be to pull out the dash, unbolt the crossbar, remove the heaterbox and completely strip, clean and reseal.

Is very satisfying to know its all nice and clean, that you did it properly, and it only takes a good solid half days work. You can also then see where its really leaking from, and also access all under the dash to repair any rust if there is any.

heating isn't an issue for me and sierra aircon's only draw air from the passenger footwell. it is more then likely ether the drain for the vent thing or the windscreen seal.

i had this drama in my 89 sierra.

there is a little black rubber hose that comes down from behind the dash and thru the firewall, into the engine bay, just check that the hose hasnt came away from the firewall.

also, mine leaked they the bonnet hinge, check that its not cracked around there too

hope this helps

-Pyro

Mine leaks from the bottom of the windshield. The foam seal is stuffed and with rust causes water to come in. It has a habit of falling on my right foot.

It really only happens in heavy rain or highway runs.

Eff

i had the same problem i found i had no seal under the window so what i did was buy some silicone and fold the window down and run a nice thick bead of it along where the rubber seal goes so once you put the window back up it squeeze out the front of the window if not leave it up and rund some along the lip under the window.
Also it might be coming through the top of the soft top where it clips on the side

mine also leaked around the ariel wire it tracked down from the windscreen

THANKS EVERONE!!!!
Looks like i'll be busy fixin this one.
Will go the strip out and take lots of pics option and see what i can find .
Cheers Steve

v8zuki wrote:mine also leaked around the ariel wire it tracked down from the windscreen

That was the main issue with me but over time the rust spread. I had to remove the rust, weld a steel plate on the bottom of the windshield surround, drilled a hole to feed the antenna wire thru, filled with bog to seal and paint. It was a bit rough, but it works and it's unseen.

Now the seal has buggered up and ive been too lazy to fix it. Maybe if Melbourne had more rain, I will get off my arse.

Eff

my 85 did the same thing so i cleaned out the box onder the dash. i had filled it with mud. so i cleaned it out best i could then taped up the vents on my bonnet. no more mud isssues. lol