Outer Limits 4x4 Board

hi guys

i have a ln 65 hilux with 3L diesel in it

when you turn the key to start the motor the motor cranks slowly like the battery has no charge

i have bought brand new battery but still have the same problem

i got no idea what it is it is electrical of course but i don't know where to begin

thanks

If you got air on check it. Sounds stupid my mates compressor was on the way out. seized up cut the belt end of starting issue: also maybe your pos cable going to the starter from the battery is damaged.

hi mate

thanks for the advice

the compressor for the air isint on the motor so thats out

i will change the lead to starter

is it posible it is the actual starter motor ?

could it be internal in the starter motor or the lead running from the solinoid on the starter to the the starter motor body

thanks its always done it but never this bad and once started and running it will crank normal

also smoke started coming from the fuse/relay box under the bonnet when cranking

thanks

Check if your earth is connected from battery to alternator as when we did an engine swap forgot that lead and did very similar except smoke came out the regulator box.
dave

yeah mate all that is plugged in

im going to clean all connections today and maybe take starter out and get it tested this week

Possibly starter motor will need rebuild.
The auto elect. can do a test in the vehicle and will measure how many amps it draws while cranking.

If way above normal it will need a simple rebuild.

hi mate

yer im thinking it is in the starter as the lead is very hot from afew cranks and the body of the starter is also very hot

Hey bud, to test the starter motor, if u get someone to turn the key so its cranking, and hit the bottom of the starter with a hammer a few times, a good smack, it should start, or the wire running over the top of the starter could be loose, i dunno what it is but it could be the problem, happened with mine, same engine..

Cheers, mitch