Outer Limits 4x4 Board

does anyone have a well proven spares list from obc. just want to make sure nothing is missed

cheers bru

Hey Bru,

at the moment I'm taking a short front axel and cv, uni and clamps, bolts and hoses.

I'm keen to see what others normally carry.

Daniels

I have one somewhere which we used a few years ago and I now have to dig it up again anyway so I'll e-mail it to you when I find it.

Cheers, Thommo.

Last year I should've pack a spare Rangie
Jonesy

MYTTUF wrote:Last year I should've pack a spare Rangie
Jonesy

or just gone in a nissan like most of the field did

Done 5 OBC, 1 in a Toyota, 3 in Nissans and 1 in a Rangie. The only time in all 5 events I visited Silver City during the event was to fix the Rangie and it happened twice and they were not minor things either.
Seriously though I have enjoyed all events, even last year in the only car to have competed all OBC!!
Jonesy

The Fish wrote:I have one somewhere which we used a few years ago and I now have to dig it up again anyway so I'll e-mail it to you when I find it.

Cheers, Thommo.

Could u post it up as i think there would be a few interested....
Without having done it before its hard to know what to take and what to leave at home. Any other tips by previous competitors would be appreciated.

I have found the list. It will seem to be excessive to most people as most of the items were carried with us. Obviously a lot of spares people carry will depend on their vehicle type and set up.

This list is from when I competed for the first time and really didn't know what to expect from the event or the reliability of the vehicle. The following year we reduced this list and this year I'd say the list of spares for Adrian's Rangie will be a lot smaller again.


Apologies for some of the terminology as it may not be technically correct

OBC SPARES
V-TO BE CARRIED T-LEAVE WITH TRAILER

REAR END - TYRE TO TYRE

TUBES x 2 (V)
TUBELESS VALVES x 4 (V)
TYRE REPAIR KIT (V)
NUTS, COLLETS, WASHERS & STUDS (V)
SHORT AXLE (V)
LONG AXLE (T)
AXLE FLANGE GASKETS x 2 (V)
INNER AXLE SEAL (V)
BEARING RETAINER NUT & WASHER (V)
INNER & OUTER WHEEL BEARINGS x 2 (V)
INNER HUB SEAL (V)
HUB (V)
LONG WHEEL STUDS x 6 (V)
PINION SEAL (V)
PINION NUT(V)
DRAIN PLUG (V)
DIFF & GASKET (T)

FRONT END - TYRE TO TYRE

CONSTANT 4WD PLATES x 2 (V)
REBUILD KIT (GASKETS, SEALS, BEARINGS ETC) (V)
HUB (V)
SPINDLE (V)
SWIVLE HUB (T)
SWIVEL HUB STUDS, NUTS AND COLLETS x 4 (V)
CV’S x 2 (V)
CV SNAP RINGS x 2 (V)
SHORT AXLE (V)
INNER AXLE SEAL (V)
DIFF (T)
DIFF GASKET (T)
PINION SEAL (V)
PINION NUT (V)
DRAIN PLUG (V)

DRIVELINE

REAR DRIVESHAFT (T)
DRIVESHAFT UNI’S x 2 (V)
TRANSFER CASE PINION SEAL (F & R) (V)
TRANSFER CASE PINION NUT (F & R) (V)
TRANSFER CASE DRAIN PLUG (V)


MOTOR

OIL FILTER (V)
AIR FILTER (V)
FUEL FILTER (V)
FAN BELTS (V)
RADIATOR HOSES x 2 (V)
HEATER HOSE (V)
THERMOSTAT (V)
RADIATOR CAP (V)

SUSPENSION

PANHARD RODS x 2 (T)
LINK RODS x 4 (T)
RADIUS ARMS x 2 (T)
REMOTE SHOCK AIRLINE (V)
MANUAL SHOCK FITTINGS x 4 (V)

DIFF LOCKS & AIR SYSTEM

PRESSURE SWITCH (V)
SOLENOIDS x 2 (V)
AIRLINE (V)
INLINE JOINERS x 4 (V)

WINCH

WINCH ROPE (V)
MOTOR & TOP HOUSING (V)
SOLENOID PACK (V)
BRAKE PACK (V)

ELECTRICAL

H3 SPOTLIGHT GLOBES x 4 (V)
12 V 30 AMP RELAYS x 4 (V)
HEADLIGHT GLOBES x 2 (V)
FUSEABLE LINK x 2 (V)
MAP READING LIGHT GLOBE (V)
ALTERNATOR BRUSHES x 4 (V)
ALTERNATOR BEARINGS x 4 (V)
REGULATOR (V)
STARTER MOTOR BRUSHES x 4 (V)
STARTER MOTOR BEARINGS x 4 (V)
ASSORTED WIRE (V)
ASSORTED LUGS (V)
HEAT SHRINK (V)
SOLDER (V)
UHF FUSES (V)
GPS FUSE (V)
ASSORTED BLADE FUSES (V)

MISC. & CONSUMABLES

CASTROL 80W/90 OIL - 4 LTRS (V)
CV GREASE (V)
WHEEL BEARING GREASE (V)
SILICONE SPRAY (V)
CRC (V)
POWER STEERING FLUID (V)
BRAKE FLUID (V)
TIE WIRE (V)
BREATHER LINE (V)
INLINE BREATHERS (V)
FUEL LINE
HELICOIL KITS



RECOVERY EQUIPMENT

TREE TRUNK PROTECTOR
20m WINCH EXT. STRAP/ROPE
SNATCH STRAP
2 x SNATCH BLOCKS
2 x CABLE DAMPENERS
4 x 3.2T BOW SHACKLES
GROUND ANCHOR
6 x GLOVES
WINCH CONTROLLER
WHISTLE
HI LIFT JACK
JACK PLATE
2 x SHOVELS
2 x MATTOCKS

RECOVERY EQUIPMENT

TREE TRUNK PROTECTOR
20m WINCH EXT. STRAP/ROPE
SNATCH STRAP
2 x SNATCH BLOCKS
2 x CABLE DAMPENERS
4 x 3.2T BOW SHACKLES
GROUND ANCHOR
6 x GLOVES
WINCH CONTROLLER
WHISTLE
HI LIFT JACK
JACK PLATE
2 x SHOVELS
2 x MATTOCKS



maybe add a torch and 12v lighting to this too ????

ZIP TIES

Luv to 4B wrote:ZIP TIES

Yeah zip ties are a must

There's heaps more consumable stuff we carry that's not on this list as we carry it all the time.

Tapes, tie-wire, welding rods & leads, hose clamps, self-taping screws, batteries for hand-held uhf, head lamp & hand held GPS are just some of these such consumables off the top of my head