ok i have a 96 leaf sprung lux i got exstended shackles and longer shocks to get a little more travel but its still the same as it was before if i was to remove some leafs from the rear packs would this allow more travel..? if so which ones. thanks daniel.
Also these are the orignal rear leaf packs also
Notice: We request that you don't just set up a new account at this time if you are a previous user.
If you used to be one of our moderators, please feel free to reach out to Chris via the facebook Outerlimits4x4 group and he will get you set back up with access should he need you.
If you used to be one of our moderators, please feel free to reach out to Chris via the facebook Outerlimits4x4 group and he will get you set back up with access should he need you.
Recovery:If you cannot access your old email address and don't remember your password, please click here to log a change of email address so you can do a password reset.
WHY WONT IT FLEX..?
Moderators: toaddog, Elmo, DUDELUX
you should get rid of the standard springs and go to a spring company
and get them to make you a set of softer springs. it all comes down to the spring rate. if your budget allows it id go for some superior engineering drop schakels. i got an 84 single cab with reset standard springs and 4 inch extended schakles, flex is ok but im goin drop schakles as soon as the budget allows it.
softer springs and drop schakles it should flex pretty good then.
and get them to make you a set of softer springs. it all comes down to the spring rate. if your budget allows it id go for some superior engineering drop schakels. i got an 84 single cab with reset standard springs and 4 inch extended schakles, flex is ok but im goin drop schakles as soon as the budget allows it.
softer springs and drop schakles it should flex pretty good then.
Posts: 3725
Joined: Wed Jun 30, 2004 1:45 pm
Joined: Wed Jun 30, 2004 1:45 pm
Location: Blue Mountains, or on a rig somewhere in bumf*ck idaho
as a general rule with leaf springs for flex you will need address the following -
1. to get maximum up travel (i.e. to the bumpstops) you will have to make sure the spring rate on the pack is matched to the weight they have to support. That means either getting them set properly professionals, or adding /removing leaves to suit the vehicle.
2. to get maximum down travel longer shackles aren't usually enough. To make the best use of the new shackles you will usually need to get a longer main and wrap leaf (which is why it has been suggested to swap your packs rear to front and go ifs rears.) Also consider removing or unbolting the pack retainer saddles that are between the axle and spring eyes to allow the pack leaves to separate. bear in mind that this has other dramas.
3. Then you will have to get a set of shocks to match your maximum up and down travel. Now that you have a light set of very flexible leaves, you will also have to match shock rates to help control flop on side slopes.
this is by no means exhaustive but a good start. hope it helps
1. to get maximum up travel (i.e. to the bumpstops) you will have to make sure the spring rate on the pack is matched to the weight they have to support. That means either getting them set properly professionals, or adding /removing leaves to suit the vehicle.
2. to get maximum down travel longer shackles aren't usually enough. To make the best use of the new shackles you will usually need to get a longer main and wrap leaf (which is why it has been suggested to swap your packs rear to front and go ifs rears.) Also consider removing or unbolting the pack retainer saddles that are between the axle and spring eyes to allow the pack leaves to separate. bear in mind that this has other dramas.
3. Then you will have to get a set of shocks to match your maximum up and down travel. Now that you have a light set of very flexible leaves, you will also have to match shock rates to help control flop on side slopes.
this is by no means exhaustive but a good start. hope it helps
http://www.populationparty.org.au/
Posts: 3725
Joined: Wed Jun 30, 2004 1:45 pm
Joined: Wed Jun 30, 2004 1:45 pm
Location: Blue Mountains, or on a rig somewhere in bumf*ck idaho
Im here for the sausage!
this is the go.spazbot wrote:put your stock rear springs in the front without the overloads and get a set of IFS rear springs and put them in the back with some 2" extended shackles, will flex pretty good them
or i hear falcon ute springs go alright in the rear.
its a tradeoff though, onroad handling vs flex.
EVERYONE LOVES A 40
www.lovells.com.au
RAW4x4
www.lovells.com.au
RAW4x4
Im here for the sausage!
And you know this because you have a Toyota???rockcrawler31 wrote:yeah right. so all he will have to worry about then is using 14.5 liters of oil per 100km as it leaks all over the highway.sclarke7171 wrote:Easy fix to get flex......
Sell it and Buy a Landrover
and landy leaf sprung trucks are even worse than luxs for flex
Ive had 2 Toyo's and 9 Landy's... only 1 Leaf sprung landy, and it out performed the fJ40 and 89 Troopy i had....
Oil leak... yeah they do and they spreads all under the body and chassis and stops rust.... unlike a Toyo...
1986 County, Auto, Locker, Maxi Crawler gears.
1987 RRC, Auto, Lockers, Himount. POS
1987 RRC, Auto, Lockers, Himount. POS
With getting maximum uptravel you also need to be wary of the spring length, to short and the spring will be flat before you are upto the bumpstops, the only way it will get to the bump stops is if the springs bends the opposite way! no good!rockcrawler31 wrote:as a general rule with leaf springs for flex you will need address the following -
1. to get maximum up travel (i.e. to the bumpstops) you will have to make sure the spring rate on the pack is matched to the weight they have to support. That means either getting them set properly professionals, or adding /removing leaves to suit the vehicle.
2. to get maximum down travel longer shackles aren't usually enough. To make the best use of the new shackles you will usually need to get a longer main and wrap leaf (which is why it has been suggested to swap your packs rear to front and go ifs rears.) Also consider removing or unbolting the pack retainer saddles that are between the axle and spring eyes to allow the pack leaves to separate. bear in mind that this has other dramas.
P.S I got some brand new IFS springs if you want them for the rear, should make those shackles work much better
U wudnt hav to worry about rust anyways wud u being made from recycled coke cans??
if u r really serious about gettin sum more leaf flex u cud always consider importing the trailgear front and rear kits. They consist of just about everything u need and r dirt cheap.
http://www.trail-gear.com/classic.html
http://www.trail-gear.com/rearsuspension.html
Boof from here and other forums has just completed SAS'ing his 98 lux using these kits and the flex is awesome to say the least. If my 4runner wasnt 5link coil rear and having a 3link SAS i wud go this path.
if u r really serious about gettin sum more leaf flex u cud always consider importing the trailgear front and rear kits. They consist of just about everything u need and r dirt cheap.
http://www.trail-gear.com/classic.html
http://www.trail-gear.com/rearsuspension.html
Boof from here and other forums has just completed SAS'ing his 98 lux using these kits and the flex is awesome to say the least. If my 4runner wasnt 5link coil rear and having a 3link SAS i wud go this path.
Posts: 3725
Joined: Wed Jun 30, 2004 1:45 pm
Joined: Wed Jun 30, 2004 1:45 pm
Location: Blue Mountains, or on a rig somewhere in bumf*ck idaho
and i know this because i spent more than my fair share of time in perenties and series rovers. I'm not a one eyed toyota man, i like landies and have a bit of a soft spot for them. soldier proof, capable, leak like bitches, rattly, and ergonomically stone age. good and bad. I just think its poor form to bag the poor fellers car when he's after a bit of advice.sclarke7171 wrote:And you know this because you have a Toyota???rockcrawler31 wrote:yeah right. so all he will have to worry about then is using 14.5 liters of oil per 100km as it leaks all over the highway.sclarke7171 wrote:Easy fix to get flex......
Sell it and Buy a Landrover
and landy leaf sprung trucks are even worse than luxs for flex
Ive had 2 Toyo's and 9 Landy's... only 1 Leaf sprung landy, and it out performed the fJ40 and 89 Troopy i had....
Oil leak... yeah they do and they spreads all under the body and chassis and stops rust.... unlike a Toyo...
http://www.populationparty.org.au/
x2 if ya not going to contribute to the discussed topic then dont post!!rockcrawler31 wrote:I just think its poor form to bag the poor fellers car when he's after a bit of advice.sclarke7171 wrote:And you know this because you have a Toyota???rockcrawler31 wrote:yeah right. so all he will have to worry about then is using 14.5 liters of oil per 100km as it leaks all over the highway.sclarke7171 wrote:Easy fix to get flex......
Sell it and Buy a Landrover
and landy leaf sprung trucks are even worse than luxs for flex
Ive had 2 Toyo's and 9 Landy's... only 1 Leaf sprung landy, and it out performed the fJ40 and 89 Troopy i had....
Oil leak... yeah they do and they spreads all under the body and chassis and stops rust.... unlike a Toyo...
mate have a look throught the members section and see what some of the other people are doing with their luxes!!
Evan
www.energizedracing.com
Support from:
Locktup 4x4
Arb Newcastle
Genr8 LED lighting
Yukon Gear & Axle
Overkill Engineering
Ruffstuff Specialties
Support from:
Locktup 4x4
Arb Newcastle
Genr8 LED lighting
Yukon Gear & Axle
Overkill Engineering
Ruffstuff Specialties
Who is online
Users browsing this forum: No registered users and 47 guests