Outer Limits 4x4 Board

HI ALL I HAVE A 89 SWB MAV AND LATELY IT HAS LEAKED WATER IN THE FRONT LEFT HAND SIDE IN THE FRONT FOOT WELL ,DOES ANY ONE HAVE ANY IDEAS THANKS

As far as know these have a problem with cracking floor pans so you might have to have a look at the floor on that side get it re-welded and use some seam sealer to seal it up a bit.

is it only when the a/c is on?
cos its common for the a/c to get condensation inside and leak from up behind the glove box

hey, could be heater core, mine just went and leaks onto floor mate next to the well,
Cheers

the drain pipe for the air con could be broken, so all the moisture would be leaking down to the floor rather than out into the engine bay

Check the rubber seal in the channel on the passengers side door, it may have twisted or come out of the groove, happened to me and led to the same thing too.

My vote is also for the A/C. When mine is working overtime and condenses a lot of moisture on the outside of the box under the glovebox, it eventually drips onto the floor.

heater or the top left corner of your window is leaking

A/C it is a daily occurence in mine.

also check the drain pipe for the cowls near the windscreen , they clog up with leaves and shit and overflow

How do you check these pipes??

thanks all but i forgot to say it has no a/c so that eliminates that

maybe windscreen. to check get a 'partner' to run a hose over the windscreen while your in the car looking all around area.

hrmmm water restrictions? go to a car wash.

embryo wrote:maybe windscreen. to check get a 'partner' to run a hose over the windscreen while your in the car looking all around area.

hrmmm water restrictions? go to a car wash.

Mine used to leak like this on the Drivers side. There are some small holes in the window rubber that block up. I never fixed mine but I think just pulling the rubber away from the glass slightly and use a pin to clear the hole. Should fix the problem.

skip-unstuck wrote:hey, could be heater core, mine just went and leaks onto floor mate next to the well,
Cheers

yep could be that, do you run coolant? if yes which you should then the water would be coolantey

turps wrote:

embryo wrote:maybe windscreen. to check get a 'partner' to run a hose over the windscreen while your in the car looking all around area.

hrmmm water restrictions? go to a car wash.

Mine used to leak like this on the Drivers side. There are some small holes in the window rubber that block up. I never fixed mine but I think just pulling the rubber away from the glass slightly and use a pin to clear the hole. Should fix the problem.

3


run a bit of window glue around the corners and it fixes it

Mine was leaking throught the windoscreen on the driver side badly, dripping down over the fuse box..........

I didn't know about and drain hole so I just stuck black scilastic around the leak. It worked

Only did that two weeks ago, wish this thread was here then

My GQ leaks when it rains onto the feet of myself and the passenger.
Apparently the GQ's crack on both corner panels (bottom of front pillars) under the cowel panel.
Also check all the plastic screws that hold the cowel panel on are there.
It leaks through the top of my windscreen seal too, right in front of my face

thanks all very help full it turned out to be a door seal so all i need now is a new one and good as new thanks all great help

hi check the rubber grommet around the heater (inlet,outlet) pipes in firewall as mine was leaking onto passenger side floor litte bit of silicon fixed it
good luck
cheers cam

my screen leaks to, had it out twice cleaned hole frame with wire brush on the grinder, repainted, new screen, prfect rubber and the thing still leaks after a big rain i'll get in the car and as soon as i start moving in comes a puddle thats being sitting in the roof, its got me stuffed thought i'd through that in so you didnt feel so bad

My GQ leaks in the passenger footwell in really heavy rain. I have narrowed it down to the snorkel braket that mounts onto the door pillar. As long as its not on my side and only occurs when its really heavy rain i'm not too worried about it as it just collects in the well of the mud mats on the floor.