Picked up a 91 suzi a couple of weeks back and found the fuel gauge needle pointing about 1cm below the "E". I just assumed that the guage was broken. But its actually working in reverse. As it gets to around half a tank it starts coming up and is at the quarter tank mark on the gauge by the time its done 250km. It then continues up as it empties out.
Has this happened to anyone else? Theres some shorts in the steering column wiring (left indicator sometimes turns on the wiper jets and wipers). Could it just be that the wires are reversed?
John
Notice: We request that you don't just set up a new account at this time if you are a previous user.
If you used to be one of our moderators, please feel free to reach out to Chris via the facebook Outerlimits4x4 group and he will get you set back up with access should he need you.
If you used to be one of our moderators, please feel free to reach out to Chris via the facebook Outerlimits4x4 group and he will get you set back up with access should he need you.
Recovery:If you cannot access your old email address and don't remember your password, please click here to log a change of email address so you can do a password reset.
Fuel Gauge working in reverse?!?!
Posts: 328
Joined: Sun Jun 27, 2004 10:35 pm
Joined: Sun Jun 27, 2004 10:35 pm
Location: Pimpin' zooks to disatisfied Jeep owners ;)
Contact:
Have you got five reverse gears and one forward gear- 'R' is for rev hard... tehehe 
Haven't heard of the fuel gauge doin' that before- mind you, my air compressor was wired into my headlight loom- lights on, lockers off, lights off, lockers on... negative switching at its best
Stranger things have happened.
Haven't heard of the fuel gauge doin' that before- mind you, my air compressor was wired into my headlight loom- lights on, lockers off, lights off, lockers on... negative switching at its best
Stranger things have happened.
People to do, Things to see ;)
Upgrade to L.E.D. on your rig! http://www.ledautolamps.com/
Upgrade to L.E.D. on your rig! http://www.ledautolamps.com/
mine plays up a little.... fill it up and it goes past E and basically sits at the bottom of the movement range, around the half tank mark, it decides to rise probably at the most to 1/4 tank, from there, if it hits the bottom of the guage again.. best bet is to call someone coz there is only abot half a litre in there!
Have a 'new'(second hand) tank that is dentless so am hoping this might solve the problem, but till i get motivated and get the time to install... $25 fuel, 200km.... and a jerry can!
Have a 'new'(second hand) tank that is dentless so am hoping this might solve the problem, but till i get motivated and get the time to install... $25 fuel, 200km.... and a jerry can!
[quote="-Nemesis-"][quote="bj on roids"]whens the aussie one start?[/quote]
A few episodes before they can it? :lol:[/quote]
A few episodes before they can it? :lol:[/quote]
That's just what mine does!foolsp33d wrote:mine plays up a little.... fill it up and it goes past E and basically sits at the bottom of the movement range, around the half tank mark, it decides to rise probably at the most to 1/4 tank, from there, if it hits the bottom of the guage again.. best bet is to call someone coz there is only abot half a litre in there!
Have a 'new'(second hand) tank that is dentless so am hoping this might solve the problem, but till i get motivated and get the time to install... $25 fuel, 200km.... and a jerry can!
have to pull the float out and recalibrate it... i figured it was just coz i had the Long ranger in it...
Spock
www.pointnshoot.org
Suzuki Auto Spares Springwood
Century Batteries
Sylverkey
Extreme Coatings
Control Synergy
Suzuki Auto Spares Springwood
Century Batteries
Sylverkey
Extreme Coatings
Control Synergy
Ahh! interesting!! how much does the long ranger hold? any clearance issues compared to a standard tank? How do you go about recalibrating the float??Pinball wrote:That's just what mine does!foolsp33d wrote:mine plays up a little.... fill it up and it goes past E and basically sits at the bottom of the movement range, around the half tank mark, it decides to rise probably at the most to 1/4 tank, from there, if it hits the bottom of the guage again.. best bet is to call someone coz there is only abot half a litre in there!
Have a 'new'(second hand) tank that is dentless so am hoping this might solve the problem, but till i get motivated and get the time to install... $25 fuel, 200km.... and a jerry can!
have to pull the float out and recalibrate it... i figured it was just coz i had the Long ranger in it...
Spock
[quote="-Nemesis-"][quote="bj on roids"]whens the aussie one start?[/quote]
A few episodes before they can it? :lol:[/quote]
A few episodes before they can it? :lol:[/quote]
Mine has died terminally now.
wire and gauge is ok as tested ground it to earth and went up fine.
any ideas? i am thinking either a sender issue (farked) or earth issue on tank.
either way is looking like dropping the tank out.
wire and gauge is ok as tested ground it to earth and went up fine.
any ideas? i am thinking either a sender issue (farked) or earth issue on tank.
either way is looking like dropping the tank out.
[url=http://www.outerlimits4x4.com/viewtopic.php?p=930942#930942&highlight=]Zook[/url]
U SUK Zook Built and Sold.
New rig is 97 80 DX. 2" list 33s
U SUK Zook Built and Sold.
New rig is 97 80 DX. 2" list 33s
I agree with Squik. (fuel float)
I thought this was a standard Zook 'feature'. Seen it on more than a few, got used to setting the trip meter when ever I filled up.
Other Zook 'Features' include:
My Zook leans to the drivers side......
Howcome I can only get 32L in my 40L tank..........
I took my sway bar off and now it corners better............
I thought this was a standard Zook 'feature'. Seen it on more than a few, got used to setting the trip meter when ever I filled up.
Other Zook 'Features' include:
My Zook leans to the drivers side......
Howcome I can only get 32L in my 40L tank..........
I took my sway bar off and now it corners better............
'89 SWB Soft Top, 6.5:1 Calmini gears, rear Lockright, 31s, pwr steering. 1.3 16vmpfi 1300 going in
When I bought my Sierra, the owner said to me, price it negotiable, because of: bla, bla,bla, and the fuel gauge doesn't work. New sender cost $80, an hours work (at night), and all was good after that.
I have noted that the gauge doesn't move at a consistant rate though. Slow down to 3/4, rushes down to a 1/2 (half full actually reads about 3/8), then it plods on after that.
I have noted that the gauge doesn't move at a consistant rate though. Slow down to 3/4, rushes down to a 1/2 (half full actually reads about 3/8), then it plods on after that.
Wheeling on completely wicked angles, without even looking stable.
Yeah Squik is right... float may have leak and therefor filling with fuel, or if theres been water in the tank can cause corrosion to jam float...
LongRanger is good for about 70L, they still make em if you ask nice and i'm reliably informed (by the guy who makes and fits em at the factory) that they will fit a LWB as well.
To recalibrate, remove sender unit, hook electrics back up (will need to run an earth), measure tank depth from sender entry to nominal empty (leave a bit of extra as a safety margin in the bottom) and then adjust float stoppers so gauge reads over that range. If it doesn't read nicely for full range, make it more accurate near empty... that's the important end.
This is all second hand btw, i haven't had time to pull mine out yet and play with it, but description was same from both Out of Town tech and mate who recently played with his due to gauge issues.
Spock
LongRanger is good for about 70L, they still make em if you ask nice and i'm reliably informed (by the guy who makes and fits em at the factory) that they will fit a LWB as well.
To recalibrate, remove sender unit, hook electrics back up (will need to run an earth), measure tank depth from sender entry to nominal empty (leave a bit of extra as a safety margin in the bottom) and then adjust float stoppers so gauge reads over that range. If it doesn't read nicely for full range, make it more accurate near empty... that's the important end.
This is all second hand btw, i haven't had time to pull mine out yet and play with it, but description was same from both Out of Town tech and mate who recently played with his due to gauge issues.
Spock
www.pointnshoot.org
Suzuki Auto Spares Springwood
Century Batteries
Sylverkey
Extreme Coatings
Control Synergy
Suzuki Auto Spares Springwood
Century Batteries
Sylverkey
Extreme Coatings
Control Synergy
Who is online
Users browsing this forum: No registered users and 72 guests