Notice: We request that you don't just set up a new account at this time if you are a previous user.
If you used to be one of our moderators, please feel free to reach out to Chris via the facebook Outerlimits4x4 group and he will get you set back up with access should he need you.
Recovery:If you cannot access your old email address and don't remember your password, please click here to log a change of email address so you can do a password reset.

Lighting butane filled tyre to explode the bead back on rim

General Tech Talk

Moderators: toaddog, TWISTY, V8Patrol, Moderators

Forum rules
Post Reply
Posts: 259
Joined: Wed Sep 07, 2005 6:04 pm
Location: Sydney

Lighting butane filled tyre to explode the bead back on rim

Post by BIG ZOOK »

It actualy worked!!!!!

I rolled the 38.5inch swamper front tyre off the rim in a deep bog hole, drove under a tree and used a hand winch to get the front off the ground becasue a jack would have sunk in the soft mud.

Punchered the end in on a portable BBQ butane can and filled the floppy tyre with the gas. Dipped a stick in petrol and held the tyre in place as best as I cound then my mate lit her up. It went bang and the tyre was perfectly seated on the rim!
In seconds it then started to vacume in with the air inside burning and we got the compressor on it just in time before it sucked the bead back off.

next time I would taek the valve out to avoid this

I burnt my hand a bit but with a crowd gathering for the show it was very very cool that it worked!
Last edited by BIG ZOOK on Mon Jun 29, 2009 2:38 pm, edited 1 time in total.
Owner of 2 FJ40's, 1 for hard offroading with no roof and 1 for on road cruising with a roof.. perfect!
Top
Posts: 2526
Joined: Wed Sep 01, 2004 8:21 am
Location: Outcast Offroad

Post by Micka »

Works well with deodourant, too. ;)
Top
Posts: 1005
Joined: Sat Aug 02, 2003 8:34 am
Location: Croydon, Victoria

Post by TRobbo »

vid?
Warn - Dont leave home without it
Top
Posts: 2297
Joined: Mon Mar 06, 2006 1:23 pm
Location: Melbourne-Australia

Post by MightyMouse »

Always wanted to see this done but no-one I know is game enough.

Glad you lived to tell :lol:
( usual disclaimers )

It seemed like a much better idea when I started it than it does now.
Top
Posts: 1072
Joined: Sat Aug 26, 2006 6:04 pm
Location: Melbourne

Post by Weiner »

http://www.youtube.com/watch?v=t7FIvAw2 ... re=related
'89 Hilux Single Cab - 3RZ, 35" Kreepy Krawlers, 4.88's, F & R Air lockers, RUF, Longfields, TG Highsteer, Highmount and no money
Top
mur
Posts: 12
Joined: Mon Jun 04, 2007 8:20 pm
Location: Melbourne

Post by mur »

The "vacuum in" wouldn’t have been air burning, all the oxygen in the tyre would have been used up with the initial explosion.
The decrease in pressure would have been the gas inside cooling down and shrinking.
Well done on getting out of a bad situation.
Top
Posts: 259
Joined: Wed Sep 07, 2005 6:04 pm
Location: Sydney

Post by BIG ZOOK »

thanks! yes was really exciting. I think I had the no fear frame of mind becasue I had had half a bottle of Jager so that helps!
Last edited by BIG ZOOK on Mon Jun 29, 2009 3:59 pm, edited 2 times in total.
Owner of 2 FJ40's, 1 for hard offroading with no roof and 1 for on road cruising with a roof.. perfect!
Top
Posts: 259
Joined: Wed Sep 07, 2005 6:04 pm
Location: Sydney

Post by BIG ZOOK »

mur wrote:The "vacuum in" wouldn’t have been air burning, all the oxygen in the tyre would have been used up with the initial explosion.
The decrease in pressure would have been the gas inside cooling down and shrinking.
Well done on getting out of a bad situation.
And it sucked the 38 in like a flat pan cake!
Owner of 2 FJ40's, 1 for hard offroading with no roof and 1 for on road cruising with a roof.. perfect!
Top
Posts: 259
Joined: Wed Sep 07, 2005 6:04 pm
Location: Sydney

Post by BIG ZOOK »

that clip shows a little squirt of gas and a little pop. I sprayed for a couple of minutes and it really exploded. now I know how its done
Owner of 2 FJ40's, 1 for hard offroading with no roof and 1 for on road cruising with a roof.. perfect!
Top
Posts: 3940
Joined: Wed Dec 27, 2006 1:09 pm
Location: Sunshine Coast Qld

Post by want33s »

Had to do this twice just yesterday...
Top
Posts: 240
Joined: Thu Dec 25, 2008 9:48 am
Location: Melbourne

Post by GU-ish »

well i learn something new everyday.
is it better to do it with the valve in or out?
Top
Posts: 1253
Joined: Thu Dec 12, 2002 1:34 am
Location: QLD

Post by Jeeps »

BIG ZOOK wrote:thanks! yes was really exciting. I think I had the no fear frame of mind becasue I had had half a bottle of Jager so that helps!
You weren't drinking and driving were you? :shock:

Light and run...

[img][img]http://i421.photobucket.com/albums/pp30 ... oyota1.jpg[/img][/img]
Top
Posts: 3098
Joined: Sat May 28, 2005 3:22 pm
Location: Melbourne, Australia

Post by PJ.zook »

Jeeps wrote:
BIG ZOOK wrote:thanks! yes was really exciting. I think I had the no fear frame of mind becasue I had had half a bottle of Jager so that helps!
You weren't drinking and driving were you? :shock:

Light and run...

[img][img]http://i421.photobucket.com/albums/pp30 ... oyota1.jpg[/img][/img]
The butane will only seat youre bead mate, its not quite magical enough to actually fit youre tyre onto the rim lol
Motorized three seater couch buildup:

http://www.outerlimits4x4.com/viewtopic ... 0&t=196047
Top
Posts: 1350
Joined: Tue Nov 25, 2008 4:48 pm
Location: Sunshine Coast - Brisbane

Post by money_killer »

^^^^^^^^^^^^^^
lol
Top
Posts: 722
Joined: Fri Sep 29, 2006 7:40 pm
Location: QLD

Post by zagan »

They did this on top gear, where they are driving to the north pole.
Top
Posts: 75
Joined: Fri Jan 09, 2009 8:04 pm
Location: Moranbah

Post by trev1 »

I've used loctite primer, a little goes a long way!
Top
Posts: 3940
Joined: Wed Dec 27, 2006 1:09 pm
Location: Sunshine Coast Qld

Post by want33s »

GU-ish wrote:well i learn something new everyday.
is it better to do it with the valve in or out?
If you can get an air hose to the valve straight after the bead seating then you can leave the valve in.
If there is a delay in getting air into tyre the vacuum may suck the bead/s back off again so it may pay to remove the valve.
Top
Posts: 1253
Joined: Thu Dec 12, 2002 1:34 am
Location: QLD

Post by Jeeps »

PJ.zook wrote:
Jeeps wrote:
BIG ZOOK wrote:thanks! yes was really exciting. I think I had the no fear frame of mind becasue I had had half a bottle of Jager so that helps!
You weren't drinking and driving were you? :shock:

Light and run...

[img][img]http://i421.photobucket.com/albums/pp30 ... oyota1.jpg[/img][/img]
The butane will only seat youre bead mate, its not quite magical enough to actually fit youre tyre onto the rim lol
i dunno... i havn't got a blue 40 series... apparently those 40 series blokes can do anything... :D
Top
Posts: 3685
Joined: Sat Sep 27, 2003 8:38 am
Location: Sydney

Contact:
Contact Roctoy

Post by Roctoy »

BIG ZOOK wrote:thanks! yes was really exciting. I think I had the no fear frame of mind becasue I had had half a bottle of Jager so that helps!
you definitely know boats Athol :D
Outers & Arms up stickers coming soon you hungry bitches!

http://www.myultimate4wd.com
GRIMACE wrote:How I miss the days of care free wheelin with the crews!
Top
Posts: 259
Joined: Wed Sep 07, 2005 6:04 pm
Location: Sydney

Post by BIG ZOOK »

Image

Image


these tyres are for sale if anyone wants. 38.5x14.5x15 Swamper SX (ones with the meaty side tread) plenty of tread. make an offer
Owner of 2 FJ40's, 1 for hard offroading with no roof and 1 for on road cruising with a roof.. perfect!
Top
Posts: 259
Joined: Wed Sep 07, 2005 6:04 pm
Location: Sydney

Post by BIG ZOOK »

Jeeps wrote:
BIG ZOOK wrote:thanks! yes was really exciting. I think I had the no fear frame of mind becasue I had had half a bottle of Jager so that helps!
You weren't drinking and driving were you? :shock:

Light and run...

[img][img]http://i421.photobucket.com/albums/pp30 ... oyota1.jpg[/img][/img]
Great pic
Owner of 2 FJ40's, 1 for hard offroading with no roof and 1 for on road cruising with a roof.. perfect!
Top
Posts: 259
Joined: Wed Sep 07, 2005 6:04 pm
Location: Sydney

Post by BIG ZOOK »

Image
Owner of 2 FJ40's, 1 for hard offroading with no roof and 1 for on road cruising with a roof.. perfect!
Top
Posts: 1400
Joined: Thu Nov 11, 2004 12:20 pm
Location: Mackay - Outerlimits; more extreme than your mum!

Post by phippsey »

Sweet as, will ensure to keep the can of smelly stuff handy :armsup:
moorey wrote:All that aside, I am yet to be convinced that RUFF is anything other than a maniacal arse hat.
Top
Posts: 1575
Joined: Thu Dec 28, 2006 6:50 pm
Location: Moronfield....

Post by nottie »

phippsey wrote:Sweet as, will ensure to keep the can of smelly stuff handy :armsup:
About a 5 second squirt of Brut was the one we used and it worked perfect.
Top
Posts: 45
Joined: Mon Jan 23, 2006 4:09 pm
Location: NSW, Australia

Post by hando »

nottie wrote:
phippsey wrote:Sweet as, will ensure to keep the can of smelly stuff handy :armsup:
About a 5 second squirt of Brut was the one we used and it worked perfect.
I bet your truck was a real chick magnet!!! :cool: :cool:
Top
Posts: 2832
Joined: Sat Oct 26, 2002 3:15 pm
Location: Ringwood East, VIC

Post by RoldIT »

BIG ZOOK wrote:these tyres are for sale if anyone wants. 38.5x14.5x15 Swamper SX (ones with the meaty side tread) plenty of tread, full of mud and slight internal melting. make an offer
Fixed. :lol:
KRiS
Top
User avatar
Tiny
Road Ranger
Posts: 10722
Joined: Fri Nov 12, 2004 12:21 pm
Location: In a town near you

Contact:
Contact Tiny

Post by Tiny »

start ya bastard works well. trick is not to use to much.
Top
Posts: 259
Joined: Wed Sep 07, 2005 6:04 pm
Location: Sydney

Post by BIG ZOOK »

RoldIT wrote:
BIG ZOOK wrote:these tyres are for sale if anyone wants. 38.5x14.5x15 Swamper SX (ones with the meaty side tread) plenty of tread, full of mud and slight internal melting. make an offer
Fixed. :lol:
and will release poisonous air when next deflated
Owner of 2 FJ40's, 1 for hard offroading with no roof and 1 for on road cruising with a roof.. perfect!
Top
Post Reply

Return to “General Tech”

Who is online

Users browsing this forum: No registered users and 142 guests