how do i check if my EGR is blocked????

Post by **peeko22** » Sat Jun 23, 2007 4:54 pm

How do i check if my EGR is blocked??? i have a 2003 3.0td (1kz-te).
Thanks

Post by **sniper** » Sat Jun 23, 2007 6:17 pm

Ask here R.A.G.4X4 or here TOYOTA SURF

Post by **Modified Toy** » Sat Jun 23, 2007 6:24 pm

Post by **sniper** » Sat Jun 23, 2007 7:02 pm

surfs will go better with a blocked EGR (apparently)

Post by **changaz** » Sun Jun 24, 2007 5:47 pm

egr will basically just pump raw exhaust gasses back into your intake in an effort to reburn and reduce harmful biproducts.
by blocking it or having it blocked, you will only be gettting fresh intake air in, but the power difference from experience will be not noticable.

Post by **tweak'e** » Sun Jun 24, 2007 6:58 pm

easy way to check to see if its blocked is to block it

preferably at the exhaust end but commanly done at the inlet manifold.

there is no top HP change as the egr system is off at full throttle, but you will notice an increase in performance at part throttle.

one thing tho....it pays to disable the butterfly as well. however i'm not familar with the setup so i can't tell you which bit to disconnect. it will run a lot better with the butterfly disabled.

Post by **peeko22** » Mon Jun 25, 2007 8:59 pm

reason i wanna check is cos i now have vacumn when i turn the car off. it reads -20 on the boost/vac gauge when i turn it off for a second then goes to zero.

someone on here said i might have it blocked and to check it and plus my turbo isnt boosting much (used to boost 11 psi) now does 8psi and struggles to do that so i thought i should check, i have been told it could be part of the problem

Outer Limits 4x4 Board

how do i check if my EGR is blocked????

how do i check if my EGR is blocked????

egr

Who is online